SMALL BASECAMP KITCHEN SMALL BASECAMP KITCHEN INSTRUCTIONS INSTRUCTION INDEX S a f e ty W a r n in g s p. 2 Set up your Small Basecamp Kitchen p. 3-7 K e lty W a r r a n ty p. 8 12SmallBasecampKitchen_INST.indd 1 09/10/12 11:01:15 AM
SAFETY INFORMATION -IMPORTANT- Read and follow all instructions before assembling and using the product. WARNINGS SAFETY WARNING DOs AND DO NOTs Everyone who uses this product should read this manual and become familiar with all safety warnings and precautions for safe assembly, use, care, maintenance, and storage. Keep this manual so you can refer to it later. BEFORE YOU START DANGER indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. WARNING indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury. CAUTION indicates a potentially hazardous situation which, if not avoided, could result in property damage. WARNING FLAMMABILITY WARNING THIS ARTICLE DOES NOT MEET THE FLAMMIBILITY REQUIRE- MENTS OF CALIFORNIA BUREAU OF HOME FURNISHINGS TECH- NICAL BULLETIN 117. CARE SHOULD BE EXERCISED NEAR OPEN FLAME OR WITH BURNING CIGARETTES. WARNING 1. THIS PRODUCT HOLDS A MAXIMUM OF 80 LBS/ 36KGS. EXCEED- ING THIS LIMIT WILL DAMAGE THE PRODUCT AND MAY CAUSE PERSONAL INJURY. 2. CARE SHOULD BE TAKEN TO AVOID TIPPING WHILE USING. 3. USE PRODUCT ONLY ON LEVEL GROUND. 2 4. TO AVOID INJURIES TO FINGERS, USE CARE WHEN FOLDING AND UNFOLDING PRODUCT. 12SmallBasecampKitchen_INST.indd 2 09/10/12 11:01:16 AM
SET UP YOUR SMALL BASECAMP KITCHEN Table Stove windscreen Frame Storage Shelf/Pantry 1. Fold one side of the frame outward as shown. (Figure 1a) Figure 1a 2. Pull the side of the frame around until it stops in the position shown. (Figure 1b) Figure 1b 3. Repeat the same procedure on the other side of the frame. (Figure 1c) Figure 1c 3 12SmallBasecampKitchen_INST.indd 3 09/10/12 11:01:16 AM
4. Pick the frame up and set it on its side. (Figure 2a) Figure 2a 5. Separate the legs of the frame by pulling the outer pieces outward as shown. (Figure 2b) Figure 2b 6. Continue pulling the legs around until the frame forms an X shape as shown. (Figure 2c) Figure 2c 4 12SmallBasecampKitchen_INST.indd 4 09/10/12 11:01:16 AM
7. Connect the two buckles on the bottom of the frame. Leave these loose until the table top has been attached. Figure 3 8. Unroll the table top. It will have two slots on both sides. The bottom will have four molded plastic rings, one on each corner. Figure 4 9. Locate and unwrap the two table support bars. Figure 5 5 12SmallBasecampKitchen_INST.indd 5 09/10/12 11:01:17 AM
10. Set the frame right side up. Attach the two table support bars to the top of the front and back sides of the frame by pushing them down over the square ends of the frame as shown. Be sure the screw heads on the support bars face outward. (Figure 6a) Figure 6a 11. Attach the molded plastic rings on the bottom of the table top to the table support bars by sliding the rings over the circular ends of the support bars (Figure 6b). Make sure the slots on the table top are closest to the back side of the table (the side away from the pantry opening). Once all four rings are attached, tighten the webbing straps on the bottom of the frame. Figure 6b 12. Connect the velcro on the four bottom corners of the pantry to flatten and stabilize the bottom shelf. Figure 6c 6 12SmallBasecampKitchen_INST.indd 6 09/10/12 11:01:17 AM
13. Insert the folding shelf supports into both shelves of the pantry (Figure 7). For best performance, be sure the fold lines on the shelf supports are opposing as shown. Figure 7 14. The pantry door can be rolled up for easy access. The velcro tabs at the top of the pantry opening connect to hold the door flap in place. (Figure 8) Figure 8 15. Attach the wind screen by sliding the tabs on the bottom of the screen into the slots on the table top. Figure 9 16. You re done! Enjoy your new Kelty Small Basecamp Kitchen. Figure 10 7 12SmallBasecampKitchen_INST.indd 7 09/10/12 11:01:17 AM
WARRANTY 09/2012 Kelty takes pride in its workmanship and undertakes to manufacture the best possible products. Kelty products (except furniture products) are warrantied to the original owner to be free from defects in material and workmanship for the life of the product. Kelty furniture products are warrantied to the original owner to be free from defects in material and workmanship for one (1) year from the original purchase date. This warranty supersedes any other warranty and is subject to the following conditions and limitations. Since no Kelty product is indestructible, Kelty s warranty does not cover defects attributable to or resulting from normal wear and tear (ie: exhausted zippers), natural hazard damage (ie: weather, animals, ultraviolet [UV] damage on tents), abuse or alteration. All products being returned require a Return Authorization number. Service under our warranty is available to the original purchaser by returning the product to any authorized Kelty dealer or by contacting our customer service department at 1-866-349-7225 (1-866-FIX-PACK) for a Return Authorization number. Proof of purchase by the original owner must accompany the product for warranty service. All products returned for warranty and repair must be properly cleaned. Items deemed insuffi ciently clean will be returned to the customer unrepaired. For more information about how to clean your product, please call our customer service department at 1-866-349-7225 (1-866-FIX-PACK). We strongly recommend that you obtain a tracking number when sending your item to Kelty! We do not take responsibility for items not received or tracked to our location. Please be sure to insure any shipment, as Kelty cannot be responsible for uninsured packages. Shipping and insurance charges to send products to the Warranty Department are the customer s responsibility. Kelty will absorb the return shipping charges. If you request that we return your product by UPS Overnight or 2nd Day Air, the additional shipping charges will be billed to you. Shipping charges for all non-warranty repairs are at the owner s expense. For products sent to the Warranty Department from outside the United States, inbound and outbound freight and any insurance charges are the customer s responsibility. If, after inspection, we determine that the product is defective, we will repair or replace it at our discretion, free of charge. If your Kelty product needs service or repair that is not covered under warranty, we will provide the necessary service at a reasonable charge. This warranty gives you, the original purchaser, specific legal rights. You may also have other rights, which vary from state to state. For additional information, please call 1-866-349-7225 to speak with a Kelty customer service representative. 8 6235 Lookout Road, Boulder, CO 80301 800.423.2320 fax 800.504.2745 www.kelty.com 12SmallBasecampKitchen_INST.indd 8 09/10/12 11:01:18 AM