Triphahn Center Roof Replacement

Transcription

1 Plotted: 9/7/08 :8 PM by haijenkit, Tanya File Name: P:\08\08.0xxx\ TRIPHHN NTR ROOF RPLMNT RFQ (PS)\rawings\Roof opyright 08. ll rights reserved. No part of this document may be reproduced in any form or by any means without permission from Wiss, Janney, lstner ssociates, Inc. (WJ). WJ disclaims any responsibility for its unauthorized use. Triphahn enter 8 West Higgins Road Hoffman states, Illinois for: by: -0.0 Titlesheet -.0 Roof Plan -.0 Metal Roof etails -. Metal Roof etails -. Metal Roof etails -.0 lternate : PV Roof etails -. lternate : PV Roof etails Hoffman states Park istrict 8 West Higgins Road Hoffman states, Illinois WJ NGINRS Wiss, Janney, lstner ssociates, Inc. RHITTS 0 Pfingsten Road MTRIL SINTISTS Northbrook, IL tel fax INX OF RWINGS GNRL NOTS -.0 lternate : PV Roof etails -.0 Translucent Panel etails -. Translucent Panel etails. ontractor to verify all conditions and dimensions in the field. Notify rchitect/ngineer (/) of any variation from rawings. o not scale rawings.. ontractor shall secure and pay for Permits, Government Fees and Licenses as required by the Village of Hoffman states for proper execution and completion of the work.. ll exits are to remain open and operable as a means of egress from the building at all times. Provide adequate protection for all building occupants and pedestrians throughout the duration of the repair work.. ontractor to provide close-up/hands-on scaffolding access for / to observe all repairs during the course of the repairs.. ontractor shall coordinate any storage of materials at the building with the Owner.. ontractor shall repair any damage to the building (walls, roof, etc.), landscaping, and adjacent properties caused by the ontractor to the satisfaction of the Owner. 7. certificate of insurance meeting the requirements as outlined by the Owner must be provided and approved prior to materials being stored on site and commencement of work. 8. Parapet Hooks will not be acceptable for swing stage rigging. 9. o not overload roof with construction materials and/or equipment. oordinate location for storage in parking lot with building. SUMMRY OF WORK ase id: In general, the scope of work includes the following:. Remove metal roofing panels and underlayment to existing insulation layer.. Over existing insulation, install plywood/polyisocyanurate composite board.. Remove metal wall panels to existing substrate.. Install felt underlayment and waterproof underlayment over plywood surface and install batten seam metal roof system.. Install flush seam metal wall panel system with continuous insulation behind.. Remove and replace translucent skylight and wall panel system. lternate No. : (Provide single-ply membrane in lieu of metal panels). Remove all existing roofing, flashings and underlayment down to the existing insulation.. Replace damaged or deteriorated insulation on a unit price basis.. Mechanically fasten " polyisocyanurate insulation and " enseck Prime gypsum roof board through the existing insulation into the steel deck at the rate of one fastener per square feet.. Fully adhere a 0 mil fleece-back PV membrane to the gypsum board substrate.. Heat weld simulated standing seam extrusions to the membrane. LOTION MP: lternate No. :. Remove all existing roofing, flashings, and insulation down to the existing metal deck.. Replace damaged or deteriorated roof deck on a unit price basis.. Mechanically fasten " polyisocyanurate insulation and " gypsum board into the steel deck at the rate of one fastener per square feet.. Install a 0 mil fully adhered PV roofing membrane and associated flashings. TRIPHHN NTR lient ate rawn hecked tlanta ustin oston hicago leveland allas enver etroit Honolulu Houston Los ngeles Minneapolis New Haven New York Princeton San Francisco Seattle Washington,.. Wiss, Janney, lstner ssociates, Inc. 0 Pfingsten Road Northbrook, Illinois tel fax Triphahn enter Hoffman states Park istrict ate NGINRS RHITTS MTRILS SINTISTS 8 West Higgins Road Hoffman states, IL 09 8 West Higgins Road Hoffman states, IL Issued for id escription September 7, 08 T PS / RW s Shown Titlesheet -0.0

2 Plotted: 9/7/08 :8 PM by haijenkit, Tanya File Name: P:\08\08.0xxx\ TRIPHHN NTR ROOF RPLMNT RFQ (PS)\rawings\Roof opyright 08. ll rights reserved. No part of this document may be reproduced in any form or by any means without permission from Wiss, Janney, lstner ssociates, Inc. (WJ). WJ disclaims any responsibility for its unauthorized use. '-0" '-0" '-0" HIMNY STK -. 7'-0" Roof Plan : /" = '-0" XHUST FN ONNSR UNIT -. MTL ROOF '-" N '-" MTL ROOF TRNSLUNT SKYLIGHT PNLS SINGL-PLY MMRN ROOF RLIF VNT XHUST FN XHUST FN TRNSLUNT SKYLIGHT PNLS '-" ONNSR UNIT 9'-0" 8'-" F 8'-" 8 MRK F ROOF RPLMNT NOT LGN S I (MTL ROOFING) - RMOV LL XISTING ROOFING, FLSHINGS, N UNRLYMNT OWN TO TH XISTING INSULTION. RPL MG OR TRIORT INSULTION ON UNIT PRI SIS. MHNILLY FSTN PLYWOO/ POLYISOYNURT OMPOSIT OR ONSISTING OF INH POLYISOYNURT INSULTION N / INH X PLYWOO THROUGH TH XISTING INSULTION INTO TH STL K T TH RT OF ON FSTNR PR SQUR FOOT. INSTLL #0 FLT UNRLMNT OVR TH SUSTRT SURF N SLF-HR WTRPROOFING UNRLYMNT T VS, SLS, WLLS, N QUIPMNT PNTRTIONS. MHNILLY FSTN GUG TTN SM MTL ROOF SYSTM N FLSHINGS. S TIL /-.0 FOR NW ROOF SSMLY. S I (TRNSLUNT SKYLIGHT PNLS) - RMOV N RPL XISTING " P TRNSLUNT SKYLIGHT SYSTM N SSOIT LOKING N FLSHINGS. INSTLL NW INTRIOR TRIM TO ONL LOKING. S I (TRNSLUNT WLL PNLS) - RMOV N RPL XISTING TRNSLUNT WLL PNL SYSTM. THIS IS TO INLU TH RPLMNT OF SOFFIT PNLS T S OF WLL PNLS. LTRNT (SINGL-PLY ROOFING) - RMOV LL XISTING ROOFING, FLSHINGS, N UNRLYMNT OWN TO TH XISTING INSULTION. RPL MG OR TRIORT INSULTION ON UNIT PRI SIS. MHNILLY FSTN POLYISOYNURT OR N / NSK PRIM GYPSUM ROOF OR THROUGH TH XISTING INSULTION INTO TH STL K T TH RT OF ON FSTNR PR SQUR FT. FULLY HR 0 MIL FL K PV MMRN TO TH GYPSUM OR SUSTRT N HT WL SIMULT STNING SM XTRUSIONS TO TH MMRN. S TIL /-.0 FOR NW ROOF SSMLY. LTRNT (LOW-SLOP ROOFING) - RMOV LL XISTING ROOFING, FLSHINGS, N INSULTION OWN TO TH XISTING MTL K. RPL MG OR TRIORT ROOF K ON UNIT PRI SIS. MHNILLY FSTN / POLYISOYNURT INSULTION N / GYPSUM OR INTO TH STL K T TH RT OF ON FSTNR PR SQUR FT. INSTLL 0 MIL FULLY HR PV ROOFING MMRN N SSOIT FLSHINGS. S TIL /-.0 FOR NW ROOF SSMLY. VRTIL WLL PNLS (S I N LTRNT ) - RMOV XISTING WLL PNLS N UNRLYMNT TO SUSTRT. INSTLL NW MOISTUR RRIR OVR XISTING SUSTRT N INSTLL NW INH POLYISOYNURT INSULTION OVR WLL SUSTRT. INSTLL NW HORIZONTL HT HNNL FURRING INHS O.. OVR NW THRML LIPS TTH TO TH XISTING SUSTRT. MHNILLY TTH NW INH FLUSH SM PNLS TO TH HORIZONTL FURRING. S TIL /-.0. TI-IN T SOUTH UILING - RMOV XISTING MMRN T RING SL. UT SL FLUSH WITH WLL OF JNT UILING T NORTH N OF SL. INSTLL WTRPROOFING UNRLYMNT ON SL N MINIMUM FT UP TH FIL OF TH ROOF. RMOV XISTING OPING N XTN WTRPROOF UNRLYMNT UP JNT WLL TO TOP OF TH PRPT. INSTLL SHT MTL ROOFING PNLS T SL N INTGRT WITH FIL PNLS. INSTLL PM MMRN OVR TOP OF PRPT WLL N SL TO PNTRTIONS. INSTLL NW OPING MTL N SL T PNTRTIONS THROUGH OPING WITH PMM LIQUI FLSHING MMRN. TYPIL GUTTR G - INSTLL WOO LOKING T PRIMTR TO MTH HIGHT OF INSULTION N NILS SSMLY. MHNILLY FSTN GUTTR TO WOO LOKING N STRIP-IN FLNG WITH WTRPROOF UNRLYMNT. ST Z-RTINR STRIP IN SLNT N NGG MTL PNL G INTO Z-RTINR. S TIL /-.0. HIMNY STK - RMOV XISTING FLSHING OLLR N SV FOR RUS. RMOV FLSHING SLV TO XPOS HIMNY STK. FRIT NW SHT MTL FLSHING SLV N INTGRT INTO MTL ROOF SYSTM. RINSTLL FLSHING OLLR N SL LONG TOP G. S TIL /-.. VNT STKS - FRIT MTL SLV PPROXIMTLY INH LRGR THN TH IMTR OF TH PIP N MHNILLY TTH TO TH OTTOM SI OF TH MTL PNL IN SOLI OF UTYL SLNT. PPROXIMTLY INH OV TH TOP OF TH OLLR, INSTLL SHT MTL STORM OLLR SUR TO TH VNT STK PIP WITH STINLSS STL RWN. INSTLL SLNT LONG TH TOP G OF TH OLLR N T TH JUNTION OF TH MTL ROOF PNL N FLSHING SLV. PLUMING VNTS (S I) - FRIT MTL SLV PPROXIMTLY INH LRGR THN TH IMTR OF TH PLUMING VNT PIP N MHNILLY TTH TO TH OTTOM SI OF TH MTL PNL IN SOLI OF UTYL SLNT. INSTLL SHT MTL FLSHING P OVR TH TOP OF TH PIP OVRLPPING TH FLSHING SLV INHS. FSTN FLSHING P TO TH FLSHING SLV WITH RIVTS. SNOW RTNTION - ST PM GSKT ON ROOF PNL N INSTLL SNOW RTNTION RKTS " O.. IN UTYL MSTI. MHNILLY FSTN RKT INTO STL K WITH STINLSS STL FSTNRS WITH PM WSHRS. INSTLL SLNT OVR FSTNRS N INSTLL OV T PRIMTR OF RKT. INSTLL TUING PR MNUFTURR ROMMNTIONS. S TIL /-.. MHNIL URS - RMOV XISTING FLSHINGS T TH PRIMTR. LOTIONS OF H QUIPMNT SUPPORT. WOO LOKING LONG TH XISTING UR RIL TO PROVI SUITL FLSHING HIGHTS. ISONNTION N RONNTION OF MHNIL QUIPMNT, IF RQUIR, SHLL INLU IN TH S I. INSTLL NW SHT MTL SKIRT FLSHINGS ST NTH TH OWNWR LG OF TH SHT MTL FLNG. TIL SIMILR TO /-.0. ROOF RINS - XISTING PRIMRY ROOF RINS TO RMIN. S TYPIL RIN TIL /-.0 FOR RQUIR PROUR FOR H RIN LOTION. NOT THT ST IRON GRTINGS MY RUS N PLSTI GRTINGS WILL NOT PT. ROOF HTH - RMOV XISTING FLSHINGS T TH PRIMTR OF ROOF HTH. TMPORRILY RMOV HTH N WOO LOKING TO PROVI SUITL FLSHING HIGHTS. INSTLL NW SHT MTL "SKIRT" FLSHINGS ST NTH TH OWNWR LG OF TH SHT MTL HTH OVR. S TIL /-.0. PLUMING VNTS (LTRNTS) - RMOV XISTING FLSHINGS T PIPS. INSTLL FIL MMRN TO PIPS, MHNILLY FSTN, N INSTLL FLSHING OOT OVR PIP. INSTLL SLNT HIN TOP G OF OOT, INSTLL STINLSS STL LMP, N INSTLL SLNT OVR TOP G OF TH OOT. lient ate rawn hecked tlanta ustin oston hicago leveland allas enver etroit Honolulu Houston Los ngeles Minneapolis New Haven New York Princeton San Francisco Seattle Washington,.. Wiss, Janney, lstner ssociates, Inc. 0 Pfingsten Road Northbrook, Illinois tel fax Triphahn enter Hoffman states Park istrict ate NGINRS RHITTS MTRILS SINTISTS 8 West Higgins Road Hoffman states, IL 09 8 West Higgins Road Hoffman states, IL Issued for id escription September 7, 08 T PS / RW s Shown Roof Plan -.0

3 Plotted: 9/7/08 :8 PM by haijenkit, Tanya File Name: P:\08\08.0xxx\ TRIPHHN NTR ROOF RPLMNT RFQ (PS)\rawings\Roof GUTTR STRP (FIL-FORM) GUTTR FLSHING SNP-ON TTN LIP SNP-ON TTN P NOPRN N PLUG "Z" RTINR STRIP ST IN SLNT PNL Metal Roof System etail : " = '-0" SLOP ":" TTN SM MTL ROOF PNL R ROSIN SLIP SHT #0 FLT UNRLYMNT NW " POLYISOYNURT/ " PLYWOO OMPOSIT NIL S XISTING " INSULTION TO RMIN XISTING MTL ROOF K R ROSIN SLIP SHT WTRPROOF UNRLYMNT NW " POLYISOYNURT / " PLYWOO OMPOSIT NIL S XISTING " INSULTION TO RMIN XISTING MTL ROOF K LP ROOF MMRN OVR IR/MOISTUR RRIR N ST IN FULL OF SLNT. NIL IN PL. MHNILLY FSTN IR/MOISTUR RRIR T OVRHNG NW ONTINUOUS LT NW HORIZONTL FURRING NW FLUSH SM MTL PNL SYSTM NW THRML LIPS NW " RIGI INSULTION " NW IR/MOISTUR RRIR. XTN ONTO TOP OF LOKING FOR OPING. NW HORIZONTL FURRING NW MTL PNL SYSTM NW " RIGI INSULTION New oping etail : " = '-0" NW 0." PRFINISH LUMINUM OPING. FSTN TO LOKING T ROOF SI. NW ONTINUOUS WOO LOKING. FSTN TO STU TRK T " O.. WITH " SRWS. XISTING WLL FRM N INSULTION S I- XISTING ROOF MMRN N SHTHING TO RMIN. XISTING TT INSULTION IN STU SPS TO RMIN. LTRNT - INSTLL NW NILS INSULTION ON TH ROOF SI OF PRPT. HR NW ROOF MMRN TO NILS. FILL STU SPS WITH SPRYFOM INSULTION. tlanta ustin oston hicago leveland allas enver etroit Honolulu Houston Los ngeles Minneapolis New Haven New York Princeton San Francisco Seattle Washington,.. NGINRS RHITTS MTRILS SINTISTS Wiss, Janney, lstner ssociates, Inc. 0 Pfingsten Road Northbrook, Illinois tel fax Triphahn enter WOO LOKING S NSSRY TO MTH HIGHT OF SSMLY NW IR/MOISTUR RRIR. HR TO SOFFIT PNL. NW THRML LIPS 8 West Higgins Road Hoffman states, IL 09 NW MTL PNL SYSTM FSTNR lient Hoffman states Park istrict opyright 08. ll rights reserved. No part of this document may be reproduced in any form or by any means without permission from Wiss, Janney, lstner ssociates, Inc. (WJ). WJ disclaims any responsibility for its unauthorized use. GL FLSHING WITH "J" LOSUR FIL-FORM PNL LG TO I.. OF "J" LOSUR SLNT WOO NILRS S NSSRY TO MTH HIGHT OF NIL S ONTINUOUS LT LOK WLL Gutter etail : " = '-0" Gable etail : " = '-0" SNP-ON TTN OVR TTN LIP WITH FSTNRS TTN SM MTL ROOF PNL R ROSIN SLIP SHT #0 FLT UNRLYMNT NW " POLYISOYNURT / " PLYWOO OMPOSIT NIL S XISTING " INSULTION TO RMIN XISTING MTL ROOF K XISTING SOFFIT PNL TO RMIN MNUFTURR'S FSI TO SOFFIT FLSHING -.0 RIVT Fascia to Soffit Flashing etail : " = '-0" ate rawn hecked 8 West Higgins Road Hoffman states, IL ate Issued for id escription September 7, 08 T PS / RW s Shown Metal Roof etails -.0

4 Plotted: 9/7/08 :8 PM by haijenkit, Tanya File Name: P:\08\08.0xxx\ TRIPHHN NTR ROOF RPLMNT RFQ (PS)\rawings\Roof SHT MTL VLLY FLSHING, RUN OWN F OF RIKT MTH TH ONTOUR OF TH MTL ROOF PNL ONTINUOUS LT FSTN " O.. SLNT Metal Roof to New ddition Transition : /" = '-0" SURF MOUNT OUNTRFLSHING FSTN " O.. " MIN. PM MMRN OVR TOP OF PRPT OPING MTL FSTN " O.. THROUGH OUNTRFLSHING S OF SLNT IN OVRLP OVRLP MTL VLLY PI " MIN. OVR ROOF PNL SNP-ON TTN OVR () TYPIL MTL ROOF PNL SNP-ON TTN OVR INSTLL SLNT T NS OF VRTIL SMS LOK PNL PNS TO NGG G MTL NOPRN N PLUG WTR UTOFF MSTI TWN PM N RKT. H FSTNR. SILION SLNT OVR FSTNR, Metal Roof to Saddle Transition : /" = '-0" " '-0" SLOP MTL ROOF PNL R ROSIN SLIP SHT UNRLYMNT SHT MTL SL ROOF SUSTRT LPIN SNOW PP HI PIP RKT T " O.. SUR TO MTL ROOF K WITH FOUR FSTNRS PR RKT TUING INSTLL PR MNUFTURR ROMMNTIONS OV OF SLNT, MIN. " ON TO OTH TH S PLT N ROOF PNL tlanta ustin oston hicago leveland allas enver etroit Honolulu Houston Los ngeles Minneapolis New Haven New York Princeton San Francisco Seattle Washington,.. NGINRS RHITTS MTRILS SINTISTS Wiss, Janney, lstner ssociates, Inc. 0 Pfingsten Road Northbrook, Illinois tel fax Triphahn enter 8 West Higgins Road Hoffman states, IL 09 SHT MTL SL FLSHING WTRPROOF UNRLYMNT SHT MTL OUNTRFLSHING INSTLL HIN OPING XISTING PV MMRN R ROSIN SLIP SHT #0 FLT UNRLYMNT NW " POLYISOYNURT/ /" PLYWOO OMPOSIT NIL S SLF-HRING PM UNR S PLT SNP-ON TTN SM lient Hoffman states Park istrict 8 West Higgins Road Hoffman states, IL 09 opyright 08. ll rights reserved. No part of this document may be reproduced in any form or by any means without permission from Wiss, Janney, lstner ssociates, Inc. (WJ). WJ disclaims any responsibility for its unauthorized use. oping etail at uilding Tie-In : " = '-0" GNRL NOTS:. LL PNTRTIONS THROUGH OPING MTL SHLL FLSH ONTO TH SURF OF TH OPING MTL WITH PMM MTRIL XISTING " INSULTION TO RMIN XISTING MTL ROOF K Snow Guard racket etail : " = '-0" " ate escription ate rawn hecked Issued for id September 7, 08 T PS / RW s Shown Metal Roof etails -.

5 Plotted: 9/7/08 :8 PM by haijenkit, Tanya File Name: P:\08\08.0xxx\ TRIPHHN NTR ROOF RPLMNT RFQ (PS)\rawings\Roof FLSHING P MTL FLSHING SLV SLV FLNG LOW SL SM FSTN FLSHING SLV FLNG TO ROOF PNL N NOT TO K SO S NOT TO FIX PNL T PNTRTION Plumbing Vent Flashing : N.T.S. SLOP MTL ROOF PNL SNP-ON TTN SM OVR R ROSIN SLIP SHT UNRLYMNT ROOF SUSTRT MIN. S OF SLNT PL TWN UPSLOP FLSHING FLNG N TOP SI OF PNL SNP-ON TTN SM OVR SLNT SNP-ON TTN SM OVR MTL ROOF PNL SHT MTL HIP P Z-LOSUR FSTN N ST IN SLNT. O NOT SL VRTIL LGS. MTL ROOF PNL INSULTION PPROPRIT FOR STK TMPRTUR SHT MTL FLSHING SLV Vent Stack Flashing : N.T.S. TMPRTUR-PPROPRIT SLNT STINLSS STL RWN SHT-MTL RIN OLLR ST SHT MTL SLV IN ONTINUOUS OF SLNT GSKT FSTNRS- SUR FLSHING SLV FLNG TO ROOF PNL N NOT TO K SO S NOT TO FIX PNL T PNTRTION " MIN. FLNG SLOP R ROSIN SLIP SHT UNRLYMNT ROOF SUSTRT tlanta ustin oston hicago leveland allas enver etroit Honolulu Houston Los ngeles Minneapolis New Haven New York Princeton San Francisco Seattle Washington,.. NGINRS RHITTS MTRILS SINTISTS Wiss, Janney, lstner ssociates, Inc. 0 Pfingsten Road Northbrook, Illinois tel fax Triphahn enter 8 West Higgins Road Hoffman states, IL 09 MTL ROOF PNL SHT MTL FLSHING NW SLNT T G OF FLSHING SKIRT SLOP SLOP lient Hoffman states Park istrict RMOV FLSHING SKIRT N RINSTLL SL NS OF SMS SLOP 8 West Higgins Road Hoffman states, IL 09 opyright 08. ll rights reserved. No part of this document may be reproduced in any form or by any means without permission from Wiss, Janney, lstner ssociates, Inc. (WJ). WJ disclaims any responsibility for its unauthorized use. FRIT FLSHING TO MTH ONTOUR OF TTNS " MIN. OVRLP N SLNT oiler Flue Flashing : N.T.S. R ROSIN SLIP SHT UNRLYMNT ROOF SUSTRT " MIN. OVRLP N SLNT NW MTL FLSHING SLV INTGRT INTO MTL ROOFING PNLS WITH MTHING PROFIL SNP-ON TTN SM OVR R ROSIN SLIP SHT UNRLYMNT NIL S SUSTRT XISTING INSULTION MTL ROOF KING Hip ap Flashing : N.T.S. ate escription ate rawn hecked Issued for id September 7, 08 T PS / RW s Shown Metal Roof etails -.

6 Plotted: 9/7/08 :8 PM by haijenkit, Tanya File Name: P:\08\08.0xxx\ TRIPHHN NTR ROOF RPLMNT RFQ (PS)\rawings\Roof PV Roof System etail (lternate ) : " = '-0" 0 MIL FL-K PV MMRN HR SIMULT STNING SM XTRUSION INSULTION FSTNR N PLT " OVR OR NW " POLYISOYNURT INSULTION XISTING " INSULTION TO RMIN XISTING MTL ROOF K SIMULT STNING SM XTRUSION HOT-IR WL 0 MIL PV MMRN, HR OVR OR NW " POLYISOYNURT INSULTION PV OT MTL " WI FLSHING STRIP, HOT-IR WL IN PL " WI LUMINUM TP OVR JOINT SHT MTL INSRTS MNUFTURR'S PROPRITRY SNOW GUR RIL WOO LOKING MTL S PLT N INTGRL PV STRIPPING SNOW GUR RKT Snow Guard etail (lternate ) : N.T.S. /" " " 0 MIL PV MMRN SIMULT STNING SM XTRUSION " MIN. tlanta ustin oston hicago leveland allas enver etroit Honolulu Houston Los ngeles Minneapolis New Haven New York Princeton San Francisco Seattle Washington,.. NGINRS RHITTS MTRILS SINTISTS Wiss, Janney, lstner ssociates, Inc. 0 Pfingsten Road Northbrook, Illinois tel fax Triphahn enter 8 West Higgins Road Hoffman states, IL 09 lient Simulated Standing Seam Profile (lternate ) : '-0" = '-0" Flashing at PV oated Metal Joints (lternate ) : " = '-0" Hoffman states Park istrict 8 West Higgins Road Hoffman states, IL 09 opyright 08. ll rights reserved. No part of this document may be reproduced in any form or by any means without permission from Wiss, Janney, lstner ssociates, Inc. (WJ). WJ disclaims any responsibility for its unauthorized use. '- /" '- /" '- /" '- /" Simulated Standing Seam Spacing Layout (lternate ) : /" = '-0" ate rawn hecked ate Issued for id escription September 7, 08 T PS / RW s Shown lternate : PV Roof etails -.0

7 Plotted: 9/7/08 :8 PM by haijenkit, Tanya File Name: P:\08\08.0xxx\ TRIPHHN NTR ROOF RPLMNT RFQ (PS)\rawings\Roof PV OT MTL WTR M PV OT MTL FSTN " O.., STGGR USING " GLVNIZ NNULR RING NILS OR OTHR PTL FSTNR ONTINUOUS LT (MIN. G.) WOO NILRS TO MTH HIGHT OF INSULTION N OVR OR Gravel Stop Metal dge (lternate ) : " = '-0" VNT STK OVR OR RIN OLLR WITH HIGH TMPRTUR SLNT PV FLSHING STRIP, HOT-IR WL 0 MIL PV MMRN NW " POLYISOYNURT INSULTION XISTING " INSULTION TO RMIN XISTING MTL ROOF K STINLSS STL HOS LMP PV FLSHING MMRN PV FLSHING STRIP, HOT-IR WL WOO NILRS TO MTH HIGHT OF OVR OR PV L MTL FSTN " O.., STGGR USING " GLVNIZ NNULR RING NILS OR OTHR PTL FSTNR MTL GUTTR SUPPORT " O.. MTL GUTTR Gutter etail (lternate ) : " = '-0" SLNT T TOP G STINLSS STL HOS LMP 0 MIL PV MMRN OVR OR NW " POLYISOYNURT INSULTION XISTING " INSULTION TO RMIN XISTING MTL ROOF K NOT: RFR TO SHT -.0 FOR NOTS RLT TO WLL PNLS tlanta ustin oston hicago leveland allas enver etroit Honolulu Houston Los ngeles Minneapolis New Haven New York Princeton San Francisco Seattle Washington,.. NGINRS RHITTS MTRILS SINTISTS Wiss, Janney, lstner ssociates, Inc. 0 Pfingsten Road Northbrook, Illinois tel fax Triphahn enter SHT MTL SLV FIRGLSS TT " MIN. PLUMING VNT PNTRTION PR-MOL PV PIP OOT 8 West Higgins Road Hoffman states, IL 09 PV S FLSHING 0 MIL PV MMRN, MHNILLY TTH OVR OR 8" MIN. 0 MIL PV MMRN, MHNILLY TTH OVR OR lient Hoffman states Park istrict NW " POLYISOYNURT INSULTION XISTING " INSULTION TO RMIN NW " POLYISOYNURT INSULTION XISTING " INSULTION TO RMIN 8 West Higgins Road Hoffman states, IL 09 XISTING MTL ROOF K XISTING MTL ROOF K opyright 08. ll rights reserved. No part of this document may be reproduced in any form or by any means without permission from Wiss, Janney, lstner ssociates, Inc. (WJ). WJ disclaims any responsibility for its unauthorized use. Vent Stack Flashing (lternate ) : " = '-0" Plumbing Vent etail (lternate ) : " = '-0" ate rawn hecked ate Issued for id escription September 7, 08 T PS / RW s Shown lternate : PV Roof etails -.

8 Plotted: 9/7/08 :8 PM by haijenkit, Tanya File Name: P:\08\08.0xxx\ TRIPHHN NTR ROOF RPLMNT RFQ (PS)\rawings\Roof Roof System etail (lternate ) : " = '-0" SLF-FLSHING UNIT ITIONL WOO LOKING, IF RQUIR (TO HIV N 8" MIN. FLSHING HIGHT) GROMMTT FSTNRS " O.. OUNTRFLSHING INSTLL HIN FLNG FLSHING TO PTL SUSTRT SPIFI SURMNT HOT-IR WL 0 MIL PV MMRN OVR OR, HR TWO LYRS OF " POLYISOYNURT INSULTION, HR XISTING " INSULTION TO RMIN IR / VPOR RRIR FULLY HR 0 MIL PV MMRN TWO LYRS OF " POLYISOYNURT INSULTION, HR IR / VPOR RRIR SUSTRT OR MHNILLY TTH TO MTL K XISTING MTL ROOF K " OVR OR, HR 8 " SUSTRT OR MHNILLY TTH TO MTL K T TH RT OF ON FSTNR PR SF. XISTING MTL ROOF K ST IRON RIN STRINR SLNT UNR MMRN T LMPING RING LMPING RING TPR INSULTION IN SUMP Roof rain etail (lternate ) : " = '-0" NON-RMOVL UNIT GROMMTT FSTNRS " O.. OUNTRFLSHING INSTLL HIN FLNG FLSHING TO PTL SUSTRT SPIFI SURMNT HOT-IR WL MNUFTURR'S RQUIR SURMNT PV MMRN FLSHING 0 MIL PV MMRN OVR OR, HR TWO LYRS OF " POLYISOYNURT INSULTION, HR IR / VPOR RRIR SUSTRT OR MHNILLY TTH TO MTL K XISTING MTL ROOF K 0 MIL PV MMRN OVR OR, HR TWO LYRS OF " POLYISOYNURT INSULTION, HR IR / VPOR RRIR SUSTRT OR MHNILLY TTH TO MTL K XISTING MTL ROOF K tlanta ustin oston hicago leveland allas enver etroit Honolulu Houston Los ngeles Minneapolis New Haven New York Princeton San Francisco Seattle Washington,.. NGINRS RHITTS MTRILS SINTISTS Wiss, Janney, lstner ssociates, Inc. 0 Pfingsten Road Northbrook, Illinois tel fax Triphahn enter 8 West Higgins Road Hoffman states, IL 09 Removable urb Flashing etail (lternate ) : " = '-0" SLNT T TOP G Non-Removable urb Flashing etail (lternate ) : " = '-0" SLNT T TOP G lient Hoffman states Park istrict opyright 08. ll rights reserved. No part of this document may be reproduced in any form or by any means without permission from Wiss, Janney, lstner ssociates, Inc. (WJ). WJ disclaims any responsibility for its unauthorized use. 8" MIN. Pipe Flashing etail (lternate ) : " = '-0" STINLSS STL HOS LMP PIP PNTRTION PV FLSHING MMRN MHNILLY FSTN MMRN T PNTRTION PV S FLSHING 0 MIL PV MMRN OVR OR, HR TWO LYRS OF " POLYISOYNURT INSULTION, HR IR / VPOR RRIR SUSTRT OR MHNILLY TTH TO MTL K XISTING MTL ROOF K 8" MIN. " MIN. Plumbing Vent etail (lternate ) : " = '-0" STINLSS STL HOS LMP PLUMING VNT PNTRTION PR-MOL PV PIP OOT MHNILLY FSTN MMRN T PNTRTION 0 MIL PV MMRN OVR OR, HR TWO LYRS OF " POLYISOYNURT INSULTION, HR IR / VPOR RRIR SUSTRT OR MHNILLY TTH TO MTL K XISTING MTL ROOF K ate rawn hecked 8 West Higgins Road Hoffman states, IL ate Issued for id escription September 7, 08 T PS / RW s Shown lternate : PV Roof etails -.0

9 Plotted: 9/7/08 :8 PM by haijenkit, Tanya File Name: P:\08\08.0xxx\ TRIPHHN NTR ROOF RPLMNT RFQ (PS)\rawings\Roof " PLSTI SHIMS ST IN FULL OF SILION SLNT TRNSLUNT PNL FLSHING Y PNL MNUFTURR UNRLYMNT MMRN. SL TO LOSUR T K LG. NW 0.00" PRFINISH LUMINUM OUNTRFLSHING SLNT WITH WP ORS T " O.. /" Wall Head etail : " = '-0" " TRNSLUNT PNL SYSTM PRFINISH 0.0" LUMINUM LOSUR " WI WITH " UPTURN LG NW TRT WOO LOKING. FSTN TO STL PLT. NW 0.0" PRFINISH LUMINUM TRIM XISTING STL PLT TO RMIN " TRNSLUNT PNL SYSTM NW MTL PNL SYSTM FOM/MTL LOSUR. SL TO PNL N PROVI WP. NW TTN SM ROOF SYSTM FLT UNRLYMNT NW PLYWOO NW RIGI INSULTION XISTING INSULTION N MTL K TO RMIN " PLSTI SHIMS ST IN FULL OF SILION SLNT TRNSLUNT PNL FLSHING Y PNL MNUFTURR UNRLYMNT MMRN SL TO LOSUR T K LG SLIP SHT (SH) SLNT N KR RO WITH OR WPS T " O.. 8" MIN. " MIN. /" Skylight Sill etail : " = '-0" " TRNSLUNT PNL SYSTM XTN "GUTTR" T HIP RFTRS OVR UPTURN LG T SILL FLSHING N N OWN TO RIN PRFINISH LUMINUM LOSUR " WI WITH " UPTURN LG NW 0.0" PRFINISH LUMINUM TRIM NW TRT WOO LOKING. FSTN TO STL M. XISTING STL M TO RMIN SMI-RIGI INSULTION tlanta ustin oston hicago leveland allas enver etroit Honolulu Houston Los ngeles Minneapolis New Haven New York Princeton San Francisco Seattle Washington,.. NGINRS RHITTS MTRILS SINTISTS Wiss, Janney, lstner ssociates, Inc. 0 Pfingsten Road Northbrook, Illinois tel fax Triphahn enter 8 West Higgins Road Hoffman states, IL 09 NW THRML LIPS NW FLSHING MMRN NW HORIZONTL FURRING lient NW PRFINISH LUMINUM OUNTRFLSHING NW ONTINUOUS LUMINUM LT WT SL PNL JOINT WITH SILION NW SLNT N KR RO WITH OR WPS T " O.. NW.00" PRFINISH FLSHING WITH RIVR. STRIP IN WITH IR RRIR MMRN. NW TRT WOO LOKING. FSTN TO STL M. -.0 Hoffman states Park istrict 8 West Higgins Road Hoffman states, IL 09 opyright 08. ll rights reserved. No part of this document may be reproduced in any form or by any means without permission from Wiss, Janney, lstner ssociates, Inc. (WJ). WJ disclaims any responsibility for its unauthorized use. " TRNSLUNT PNL SYSTM " PLSTI SHIMS NW WOO LOKING, NHOR T " O.. NW PRFINISH LUMINUM TRIM /" Skylight Head etail : " = '-0" NW " THIK SMI-RIGI INSULTION NW SHTHING NW ONTINUOUS LUMINUM TRIM (TWO-PI) -. & T INTRIOR ate rawn hecked ate Issued for id escription September 7, 08 T PS / RW s Shown Translucent Panel etails -.0

10 Plotted: 9/7/08 :8 PM by haijenkit, Tanya File Name: P:\08\08.0xxx\ TRIPHHN NTR ROOF RPLMNT RFQ (PS)\rawings\Roof XISTING STL STU FRMING. RPIR S NSSRY. / TO INSPT FRMING FTR XISTING TRNSLUNT PNLS R RMOV TO TRMIN RPIRS RQUIR. " TRNSLUNT PNL SYSTM -. ONTINUOUS SLNT ONTINUOUS 0.0" PRFINISH LUMINUM TRIM ONTINUOUS WOO LOKING SLNT /" Wall Sill etail : " = '-0" XISTING STUS T " O.. NW " TYP X GYPSUM SHTHING NW IR/MOISTUR RRIR PRFORM SILION TO SL IR/MOISTUR RRIR TO STORFRONT NW " RIGI INSULTION NW WOO LOKING S NSSRY TO SUPPORT IR RRIR. INSTLL TWN STORFRONT LIPS. XISTING STORFRONT SYSTM TO RMIN OUNTRSUNK FSTNRS " TRNSLUNT PNL SYSTM FILL SP T N OF FLOOR WITH SMI-RIGI INSULTION NW ONTINUOUS S.S. TRMINTION LOSUR ST IN SLNT " TRNSLUNT PNL SYSTM FLSHING MMRN ONTINUOUS PLSTI SHIMS ST IN SLNT. PROVI " GP TWN. TRNSLUNT PNL FLSHING (PRFINISH LUMINUM) Y PNL MNUFTURR NW SLNT N KR RO WITH OR WPS T " O.. FILL WITH SLNT " RIGI INSULTION. TP LL JOINTS WITH FOIL TP. NW THROUGH-WLL FLSHING. FORM RIVR T OTTOM G. PRFINISH LUMINUM RIVTS NW IR/MOISTUR RRIR NW 0.00" PRFINISH LUMINUM PNLS. RIVT TO LIPS WITH OLOR MTH RIVTS. NW SLNT N KR RO UT " P ONTINUOUS RGLT IN MSONRY FOR LOSUR NW 0.00" PRFINISH LUMINUM LOSUR NW SLNT JOINTS /" /" " " nlarged Wall Sill etail : " = '-0" S.S. LIPS T " O.. (STGGR) SLNT JOINT /8" PNL IMNSION /8" XISTING STL STU FRMING. RPIR S NSSRY. / TO INSPT FRMING FTR XISTING TRNSLUNT PNLS R RMOV TO TRMIN RPIRS RQUIR. XISTING STL NGL TO RMIN. LN N PINT NW ONTINUOUS X LOKING NW " TYP X GYPSUM SHTHING " RIGI INSULTION. TP LL JOINTS WITH FOIL TP. NW 0.00" PRFINISH LUMINUM SOFFIT PNLS /" tlanta ustin oston hicago leveland allas enver etroit Honolulu Houston Los ngeles Minneapolis New Haven New York Princeton San Francisco Seattle Washington,.. NGINRS RHITTS MTRILS SINTISTS Wiss, Janney, lstner ssociates, Inc. 0 Pfingsten Road Northbrook, Illinois tel fax Triphahn enter XISTING MZZNIN FLOOR. VRIFY ONSTRUTION IN FIL. /" 8 West Higgins Road Hoffman states, IL 09 PRFINISH STL LIP NGLS TO MTH MULLION OLOR. SIGN N NHORG TO Y TRNSLUNT PNL ONTRTOR. Wall Panel Lateral nchorage etail : " = '-0" WT SL PNLS WITH SILION. INSTLL T FLT PROFIL. SLNT N KR RO Wall Jamb and atten etail : " = '-0" lient Hoffman states Park istrict 8 West Higgins Road Hoffman states, IL 09 " TRNSLUNT PNL SYSTM opyright 08. ll rights reserved. No part of this document may be reproduced in any form or by any means without permission from Wiss, Janney, lstner ssociates, Inc. (WJ). WJ disclaims any responsibility for its unauthorized use. /" Ridge etail : " = '-0" NW SLNT JOINTS () NW PRFINISH LUMINUM TRIM NW ONTINUOUS WOO LOKING. NHOR TO STL M. ONTINUOUS SLNT XISTING STL M " ONTINUOUS PLSTI SHIMS ST IN SLNT PRFINISH LUMINUM "GUTTR" WITH HMM GS TURN UP " /8" Roof atten etail : " = '-0" WT SL H N JMS T LL PNLS WITH SILION. INSTLL T FLT PROFIL. /" ate rawn hecked ate Issued for id escription September 7, 08 T PS / RW s Shown Translucent Panel etails -.